Expert Volvo maintenance and repair from ASE-certified technicians at ExperTec Automotive Costa Mesa.
Volvo drivers in Costa Mesa tend to value two things: safety and comfort that lasts. Whether it is an XC60 headed down Newport Blvd for a coastal trip or an S60 making short errands to South Coast Plaza, keeping those qualities intact takes care from a shop that understands Swedish engineering.
ExperTec Automotive’s ASE-certified technicians work on the full Volvo range, including the XC90, XC60, XC40, S60, V60, S90 and V90 Cross Country, plus T8 plug-in hybrids and electric models. We use dealer-level scan tools to read Volvo modules, reset service reminders and diagnose driver-assistance warnings, and we install OEM-quality parts throughout.
Living near the coast means salt air that can corrode brake hardware and electrical connectors, so our inspections look closely at both. Just off the 55 and close to the OC Fair grounds, we bring 30+ years in Orange County, 10 consecutive years voted OC’s best auto repair and a 3yr/36k nationwide warranty to every Volvo.
Modern Volvos follow a fixed schedule of numbered services about every 10,000 miles or 12 months, whichever comes first, and the driver display shows a service reminder as each interval approaches. Every visit includes an oil and filter change with Volvo-approved synthetic oil and a multipoint inspection, while larger services add items like engine and cabin air filters, brake fluid, spark plugs and drive belt inspection at specific mileage steps; exact intervals vary by model/engine. Volvo considers automatic transmission fluid long-life, but many independent shops, including ours, recommend inspecting or changing it at higher mileage, especially in heat. T8 plug-in hybrids follow the same schedule plus hybrid system checks, and fully electric models follow a lighter time-based schedule.
Upon completion of the standard maintenance tasks we provide an additional 30-point inspection to make sure that all components in your Volvo are up to date and working well.
~10,000 miles or 12 months
~30,000 / 60,000 miles and beyond (varies by model/engine)
At ExperTec Automotive, we’ve been repairing Volvo vehicles in Orange County for over 30 years. Even well-built Volvo models develop specific problems as they age, and 55 Freeway commutes and coastal salt air add to the wear. Our Costa Mesa technicians diagnose these issues quickly, follow Volvo factory repair procedures and use quality parts you can trust.
Some 2.0L Drive-E four-cylinder engines, used in many roughly 2015 to 2019 T5 and T6 models such as the XC60, XC90, S60 and V60, were widely reported to burn oil between services due to piston ring issues. Watch for low oil warnings or the need to top off often. We perform a documented oil consumption test, inspect the PCV system and explain repair options.
The plastic coolant expansion tank on many Volvos can crack or leak at its seams or cap with age and heat cycles, causing slow coolant loss, a sweet smell after driving or a low coolant warning. Ignoring it can lead to overheating. We pressure-test the cooling system, replace the tank and cap with OEM-quality parts and check hoses and the water pump while we are there.
Older Volvo five- and six-cylinder engines rely on a PCV oil trap, sometimes called the flame trap, that can clog with sludge, building up crankcase pressure. Symptoms include a whistle at idle, oil leaks from seals, oil around the dipstick and higher oil consumption. Drive-E engines can have related PCV issues. We test crankcase pressure and replace the separator, hoses and seals.
Many Volvos use an Aisin automatic transmission that can develop harsh or delayed shifts, flare between gears or a bump when coming to a stop as fluid ages, especially in heat and heavy traffic. Volvo considers the fluid long-life, but we often find it worn at higher mileage. We scan adaptation data, check fluid condition, perform fluid exchanges and reset adaptations.
Volvo’s older five-cylinder engines, used in models such as the S60, V70, XC70 and XC90 through roughly the mid-2010s, use a timing belt that must be replaced on a mileage and age schedule, often around 100,000 miles or 10 years, varying by model/engine. Because these are interference engines, a broken belt causes major damage. We replace the belt, tensioner, idler and water pump together.
Older all-wheel-drive Volvos, including the XC90, XC70, S60 and V70, use an angle gear, or bevel gear, to send power to the rear wheels. It runs hot and its fluid is rarely changed, which can lead to leaks, worn seals and eventually failure that leaves only front-wheel drive. We inspect for leaks, service the angle gear fluid and replace failed units.
Our Costa Mesa auto repair shop is on Newport Boulevard, the main route between the 55 Freeway and Newport Beach, a short drive from Triangle Square and the OC Fair & Event Center.
Between 55 Freeway commutes, coastal trips to Newport and short around-town errands, Costa Mesa cars see a lot of heat, salt air and stop-and-go driving. That’s why our Costa Mesa technicians focus on catching problems early, explaining your options clearly and fixing it right the first time.
Neighborhoods we serve: Eastside Costa Mesa, Westside Costa Mesa, Mesa Verde, College Park, South Coast Metro, Newport Heights.
Nearby cities: Newport Beach, Irvine, Santa Ana, Huntington Beach, Fountain Valley.
Proud member of the Costa Mesa Chamber of Commerce.
1934 Newport Blvd, Costa Mesa, CA 92627
Mon–Fri 7:30AM–6PM · Sat 7:30AM–4PM · Sun Closed
Book in Costa MesaGet DirectionsView Shop DetailsOur Costa Mesa shop is at 1934 Newport Blvd, Costa Mesa, CA 92627. Call (949) 645-7722 or book online.
Monday through Friday 7:30 AM to 6:00 PM and Saturday 7:30 AM to 4:00 PM. We are closed on Sunday.
For most Orange County drivers we recommend it. Heat and stop-and-go traffic wear transmission fluid faster than ideal conditions, and a fluid exchange at higher mileage, often somewhere around 60,000 miles, is inexpensive protection for a costly component.
Yes. Every repair includes a 3 Year / 36,000 Mile Nationwide Warranty plus 12 Month / 12,000 Mile Roadside Assistance.
Book online in minutes at ExperTec Automotive Costa Mesa. Online appointments are drop-off appointments; for a waiting appointment, please call the shop.
Mon–Fri 7:30AM–6PM · Sat 7:30AM–4PM. All appointments booked online are drop-off appointments. For waiting appointments, please call the shop.
We work with most extended warranty companies. See how it works →
7680 Talbert Ave, Huntington Beach, CA 92648
Huntington Beach Auto Repair →Book in Huntington BeachView Shop1934 Newport Blvd, Costa Mesa, CA 92627
Costa Mesa Auto Repair →Book in Costa MesaView Shop
Voted Orange County’s Best Auto Repair 10 years in a row by readers of the Orange County Register. Book online in minutes or call your nearest shop.
Gary
Jose
Julie
Ronnie
Cesar
David